hi my son just picked up a 140cc bike for next to nothing as it wasent running, we soon found the reason was it didn't have a spark plug cause the previous owner had striped the spark plug thread in the head, my question is can you get some sort of repair kit like a helicoil ect with the head...
hi guys my son just picked up an elstar with an electric start/kick start motor ive been tol its either a 230cc or 250cc zongshein motor its got ZS167FMM *88100296* Stamped on the eng below the eng sprocket and the Vin is ELSESTL0700B11396 Manufactured 2008 its got a crappy torch spark plug in...
ok thanks my67xr n what plug be the best heat range to run in it also what oil as it needs some and do they have oil filters n where would it be located thanks
hi my son just picked up this complete n good cond elstar for $200 , the vin plate is as follows VIN-ELSESTCO7005113 ENG NUMBER- 88100296 MANUFACTURE DATE-2008
and the engine number on the motor is -ZS167FMM *88100296* the guy who he got it off said its a 200cc but the motor looks identical...
ok yea my rectifier can only plug in one way its got a 6 pin white flat plug and the wireing coming from the stator has 2 sets 1 has a flat white plug 6pin n that go's to bikes wireing harness the other has a square green plug with 6 wires but carnt find a place for it n mymy67xr seems to...
I just found the old part number on the battery n its a 4AH battery ive cleaned up all the earth points and made sure all the conectors are clean and tight fitting,cleaned them out with some swich cleaning erosol fluid my mate kindly donaterd thanks to Telstra lol made sure the rectifier has a...
ok thanks space is no probs if I remember correctly to check the charging voltage u put the multimeter on the battery when its running to see wat its getting correct
thanks for ya help guys,
the remote had dirty contacts.
i got the starter button working it turned out that the green/yellow wire was broken inside,
I did a test on the wire and nothing was coming through,
so I cut it and ran a new bit, low and behold the mongrel burst into life.
its the...
yea I actually got a new remote starter switch and I tried it on it, but the bloody thing still wouldn't play ball.
I wouldn't be bothered with the elec start, but my 14 yr old son can't kick it over as it's got too much compression for him.
and he has got a crook r/h knee, so i need to get...
i'll have to check the ignition as its falling apart, the goose who taped it up had it sticky taped together and hid it under the tank.
and yeah, that's the only thing I haven't tried yet green/yellow to pos battery.
I just found a new ignition switch with key in all my spares on the racks...